Your payment information is processed securely. We do not store credit card details nor have access to your credit card information.
Description
The Cube Orange + IMU V8
Offers faster H7 SOC with 1 MB RAM
Upgraded triple redundant IMU sensors
Onboard 16 KB SPI FRAM
Fully Cubepilot carrier board compatible
Interface: SPI
The Cube Orange + IMU V8 provides power routing, over/under voltage detection and protection, filtering, switching, current-limiting, and transient suppression for peripherals. Two sets of IMU are vibration-isolated mechanically, reducing the effect of frame vibration on state estimation.
Fully Cubepilot carrier board compatible, all inputs and outputs go through an 80-Pin DF17 connector, allowing a plug-in solution for manufacturers of commercial systems. IMUs are temperature-controlled by onboard heating resistors, allowing the optimum working temperature of IMUs. The entire flight management unit (FMU) and inertial management unit (IMU) are housed in a relatively small form factor (a cube).
Power outputs to peripherals feature ESD and EMI filtering, and the power supply protection scheme ensures that no more than 5.5 V is presented to peripheral devices. Power is disconnected from the peripherals when the available supply voltage falls below 2.7 V, or rises above approximately 5.7 V.
The Cube has eight PWM outputs that are connected to IO and can be controlled by IO directly via R/C input and onboard mixing even if FMU is not active (failsafe/manual mode). Multiple update rates can be supported on these outputs in three groups; one group of four and two groups of two. PWM signal rates up to 400 Hz can be supported. These 8 PWMs are output ONLY and are capable of driving up to 50 mA each, but only a total of 100 mA for the 8.
If you are not satisfied for whatever reason with a Product you bought on the Site, it is possible to return it for refund within 30 days from the date you received it unless otherwise indicated in the Product listing. You must first advise the Vendor associated with your order in your account to obtain a return authorization (‘’RA’’) number before returning a Product. (‘’RA’’) numbers are valid for 30 days, within which time the returned Products should be received by the Vendor. No returns will be accepted without having previously obtained an (‘’RA’’) number. The Product must then be returned in its original packaging (in perfect condition for resale) with its receipt and your (‘’RA’’) number. Reimbursement will be denied for any Products which do not conform to the above mentioned conditions.
Build-it-yourself Robot Parts are not refundable once assembled. Robots & Kits requiring assembly or soldering are also not refundable once assembled, soldered or modified in any way. All sales of robotic software and apps are final and cannot be refunded or exchanged. Returns are not accepted on special orders and clearance items except when they are found defective, in which case the Product may be repaired or replaced at the Vendor’s discretion. 20% Restocking fees may apply if you are returning a large quantity of the same Product that was ordered specifically for you from the manufacturer.
Please note that all items will be reimbursed within 7 to 14 days of receiving the Product (shipping fees excluded). You must also cover the cost of returning the Product. Shipping fees will only be refunded if the return is a result of a shipping error on our part. Cleaning fees of USD 100 may also be charged if a domestic robot is returned and has not been properly cleaned.