Arducam CSI to HDMI Cable Extension Module (2pk)

ArduCAMSKU: RB-Adu-36
Manufacturer #: B0091

Price  :
Sale price $17.42

Price includes Tariffs (in USA).  Shipping calculated at checkout.

Stock  :

Re-stocking soon See due date

Notify me when this product is in stock

Description

  • Supports Raspberry Pi boards ( Raspberry Pi Model B+ 512MB RAM, Raspberry Pi 2 Model B 1 GB or Raspberry Pi 3 B+)
  • Designed for the camera board V1 ArduCam 5 MP Mini Camera OV5647 1080p for Raspberry Pi , Raspberry Pi Camera Module V2 or Arducam 8MP Sony IMX219 Camera Module w/ CS lens 2718 (Raspberry Pi)
  • Works with HDMI cables up to 10 meters
  • Reserved microphone and headphone jack for audio or GPIO signals

The Arducam CSI to HDMI Cable Extension Module (2pk) is designed for V1 and V2 Raspberry Pi camera board to extend the camera over the long cables while keeping the high-speed CSI signals away from noise and interference. By using high-speed HDMI cable, the camera can run over 10 meters, that high extend the usage of the Raspberry Pi cameras.

Arducam CSI to HDMI Cable Extension Module (2pk)

In addition, the adapter board provides another 3 signals to be extended with the camera signals together via the headphone jack connector.

  • 2 x Pcs Arducam CSI to HDMI Cable Extension Module
  • 2 x Pcs 80mm 15pin FPC cable
  • 4 x Sets M2 screw
  • 27.63 x 25.00mm
  • Supported for Raspberry Pi A/B/B+ boards or Raspberry Pi 2B board or Raspberry Pi 3B board 
  • Supported for Raspberry Pi camera board V1 (5MP OV5647) or Raspberry Pi camera board V2 (8MP IMX219) 
  • HDMI cables can be up to 10 meters (more than 10 meters wasn't tested)
  • Three additional solder pads are available (same signals as headphone jack) 

Customer Reviews

Based on 2 reviews
50%
(1)
0%
(0)
50%
(1)
0%
(0)
0%
(0)
G
Geraldine
Very useful

Nice product! This is a very easy way to extend the range of the Pi camera module using an HDMI cable. It is also easy to find 3D designs of the case for the camera with this adapter.

A
Alexandre
Spec Sheet is wrong

The mechanical drawing puts the mounting holes at 12.5mm center to center, but they're actually exactly a half inch center to center. I had some PCBs specced using the mechanical drawing, and I have to toss them in the bin.

Estimate shipping

WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.

You may also like