Description
- Lynxmotion Crazy2Fly Drone Kit (Hardware Only)
- All G10 (Fiberglass) frame parts to build a Crazy2Fly frame
- Complete Hardware Bag
- 1x Lynxmotion Battery Velcro Strap
- 4x Brushless Rotor Motor 1000Kv 15A
- 4x
Lynxmotion 12A Multirotor ESC 1A BEC (With Connectors) - 2x Pair of 8x4.5 Clockwise Propellers
- 2x Pair of 8x4.5 Counter Clockwise Propellers
- 1x Power Wiring Harness
- 1x Receiver to Flight Controller Wiring Harness
Note: Propeller colors might change without notice (usually two pairs of black and two pairs of orange)
Requires (sold separately)
- Flight Controller (UAV & Drone Flight Controllers )
- Battery: 11.1V (3S), 20C (min) 2000 mAh (min)
- 5-channel remote control (programming ESCs is needed)
- Overall: 38 x 38 x 11 cm (L x W x H)
- Weight: 250g
Motor Specifications:
- Optimized for 2-4S LiPo Cells (11.1V to 14.8V nominal)
- Kv: 1000 (RPM/Volt)
- Max Continuous current: 15A
- Dimensions: 27.7 x 32 mm
- Weight: 58g
- 3 mm bullet connectors
- 300 mm wires length
Electronic Speed Controller Specifications:
- 12A continuous discharge, 16A burst
- Ideal for 2-4S LiPo, 6-12 Cells NiMh
- Provides 5V, 1A Linear Mode BEC
- High-speed SimonK Firmware for MultiRotors
- Programmable via RC Transmitter
- Deans connector for power input
- 3 mm female bullet connectors for motors
- 200 mm long signal wires with JR (servo) connection
- 125 mm long power wires
- 35 mm long motor wires
- Size: 27 x 22 x 7 mm
- Weight: 9g
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.










