2'' Stroke 150lb Force Linear Actuator

Firgelli AutomationsSKU: RB-Fra-13
Manufacturer #: FA-150-S-12-2

Price  :
Sale price $129.99

Price includes Tariffs (in USA).  Shipping calculated at checkout.

Stock  :
Only 2 units left

Description

  • Force: 150lbs 
  • Stroke: 2"
  • 12vdc nominal voltage 
  • 3amp current draw at full load 
  • Built in limit switches, not movable
  • Speed at no load: 10 mm/sec (0.4"/sec)
  • Metal gear ratio: 20:1
  • IP54 Rating (splash and dust resistant) 
  • 2-wire harness, reverse polarity to change direction 



The Firgelli Automations 2" Stroke 150lb Force Linear Actuator is ideally suited to applications that require quiet and smooth linear operation. They come with built in limit switches (not movable), Aluminum case, 2 clevises, one on each end.

Do you need waterproof protection for your actuator? Add a Rubber Protector Boot for Classic Linear Actuators to your design (Sold separately)

Hole to Hole dimensions:

  • Collapsed length: 6.3in
  • Extended Length: 8.3in


2'' Stroke 150lb Force Linear Actuator



Customer Reviews

Based on 8 reviews
13%
(1)
88%
(7)
0%
(0)
0%
(0)
0%
(0)
J
John Paul
Good quality for the money

Been using these for years, high force at lower amperage than similar linear actuators. The extendable end of the rod is made of two fused parts (an outer tube with an inner core) which makes modification difficult but when being used just with the standard rod mount works perfectly.

J
John Paul
Works alright

One thing I should note is that the stroke length is 1-7/8" not 2. So prepare your mechanisms accordingly. I've used these often and this is common to every one..

J
John Paul
Good value for the output

Works well with AA NiMH rechargeable battery packs. Maximum current from good NiMH batteries is about 4 amps and this actuator draws up to 3 amps.

J
John Paul
Adequate quality

Shaft has a little play in the mechanism, not suitable for side loads unless externally supported. Weight measured on a digital scale is 0.811 kg Contrary to the dimensions present here, the shaft diameter is actually 0.784 inches. Overall the actuator functions well when you compensate for the dimensional discrepancies. I've been using these for years.

J
John Paul
Adjustable shaft

The length of the shaft can be slightly adjusted by rotating. Probably adjust the stroke by about 1/8 inch. Which is nice if you want to fine tune the beginning or end position in your mechanism.

Estimate shipping

WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.

You may also like