Description
1x Molex 200mm wire harness
1x Rear Hinge / Hinge base / Hinge shaft
3x M3 Nuts
3x M2.5x5 screws
1x Socket set screw
57.4 mm (L)
29.9 mm (W)
15 mm (H) (excluding rod end tip and rear hinge)
Weight: 41 g
Microcontroller: 32 bit ARM Core with 4096 Resolution A/D Converter
Position Sensor: 10kOhm Linear Potentiometer
Motor: Core DC
Stroke: 26mm (Extendable to 29mm)
Positional Accuracy: 0.03mm (30um) Unidirectional
Input Voltage: 7.4V
Rated Load: 6N
Maximum Applicable Load: 12N (at 20% Duty Rate)
Speed: 36mm/sec (at No Load)
Maximum Duty Rate: 50%
Gear: Engineering Plastic Gears
Gear Ratio: 10:1
Rod: Engineering Plastic Rod
Mechanical Backlash: 0.03mm (30um)
Current Consumption: 250mA at Rated, 30mA at Idle
Audible Noise: 50dB at 1m
Data Communication & Protocol: RS 485/IR Robot Open Protocol
LED Indication: 7 Error Indications (Overload, Checksum, Range, Overheat, Stroke Limit, Input Voltage, Instruction Error)
Parameter Setting: Programmable (More than 50 Operating and Setting Parameters)
Ingress Protection: IP 54 (Dust & Water Tight)
Operating Temperature: 10 degrees C to 60 degrees C
Wire Harness: Molex to Molex Type (Molex 0510650400, 4 Pins) / 200mm Length, 0.08 60 (22AWG)
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.