Description
- Lynxmotion Hunter VTail 500 Drone Kit (Hardware Only)
- All G10 (Fiberglass) frame parts to build a VTail 500 frame
- Complete Hardware Bag
- 2x Lynxmotion Battery Velcro Strap
- 4x Brushless Rotor Motor 930Kv 28.9A
- 4x
Lynxmotion 30A Multirotor ESC 1A BEC (With Connectors) - 2x Pair of 10x4.5 Clockwise Propellers
- 2x Pair of 10x4.5 Counter Clockwise Propellers
- 1x Power Wiring Harness
- 1x Receiver to Flight Controller Wiring Harness
Note: Propeller colors might change without notice (usually two pair of black and two of orange)
Requires (sold separately)
- Flight Controller (UAV & Drone Flight Controllers )
- Battery: 11.1V (3S), 20C (min) 2800mAh (min)
- 5 channel remote control (programming ESCs is needed)
Motor Specifications:
- Optimized for 2-4S LiPo Cells (11.1 to 14.8 V nominal)
- Kv: 930 (RPM/Volt)
- Max Continuous current: 28.9 A
- Dimensions: 27.7 x 37 mm
- Weight: 74g
- 4 mm bullet connectors
- 350 mm wires length
Electronic Speed Controller Specifications:
- 30A continuous discharge, 40A burst
- Ideal for 2-4S LiPo, 6-12 Cells NiMh
- Provides 5V, 1A Linear Mode BEC
- High speed SimonK Firmware for MultiRotors
- Programmable via RC Transmitter
- Deans connector for power input
- 4mm female bullet connectors for motors
- 200mm long signal wires with JR (servo) connection
- 125mm long power wires
- 35mm long motor wires
- Size: 27 x 22 x 7 mm
- Weight: 9g
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.










