Description
- 1x MegaMoto Dual Channel H-Bridge Motor Controller for Arduino 13A, 5-28V
- Supply voltage: 5V to 28V (maximum battery rating of 24V)
- Continuous output current: 13A
- Surge output current: 30A for 5 seconds
- Power chips: 2 BTN7960B
- On resistance: 0.016 ohm maximum at 25°C
- PWM frequency: DC to 20kHz
- Logic interface: 3V - 5V, minimum of 1 pin required
- Logic inputs: Jumper selectable for enable and PWM source
- Current sense outputs: 0.0745V per Amp, 2.98V at 40A
- Current sense pins: Jumper selectable for the connected analog input
- Current and temperature limiting: Integrated into power chips
- Power connectors: 2 screw terminals (14AWG wire) and solder pads for power wires
- Enclosure: None
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.