Description
- 1x Robot Power MegaMoto Plus Dual Channel H-Bridge Motor Controller for Arduino 20A, 5-28V
- Supply voltage: 5V to 28V (maximum battery rating of 24V)
- Continuous output current: 20A (25A with fan)
- Surge output current: 40A for 5 seconds
- Power chips: 2 BTN7960B
- On resistance: Maximum 0.016 ohm at 25°C
- PWM frequency: DC to 20 kHz
- Logic interface: 3V - 5V, minimum 1 pin required
- Logic inputs: Jumper selectable for enable and PWM source
- Current sense outputs: 0.0745V per Amp, 2.98V at 40A
- Current sense pins: Jumper selectable for analog input connection
- Current and temperature limiting: Integrated into power chips
- Power connectors: 2 screw terminals (14AWG wire) and solder pads for power wires
- Enclosure: None
- Weight: 37 g
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.