Description
- 1x Waveshare 2.7" E-Ink Display HAT 264x176 for Raspberry Pi
- 1x 2.7inch e-Paper HAT
- 2x RPi screws pack (2pcs)
- 1x PH2.0 20cm 8pin
- 57.288 x 38.192 mm
- Resolution: 264×176 pixels
- Viewing angle: greater than 170°
- Display color: black and white
- Grey scale: 4 levels
- Communication: SPI
- Display panel: e-paper
- Experience: paper-like
- Environment: ambient light required
- Display type: passively reflective
- No backlight; retains last content display when powered down
- Ultra-low power consumption; power needed only for refreshing
- Onboard 4 keys for extended applications
- Standard Raspberry Pi 40-pin GPIO extension header; supports Raspberry Pi series boards and Jetson Nano
- SPI interface for connecting with controller boards like Raspberry Pi, Arduino, and STM32
- Onboard voltage translator; compatible with 3.3V/5V MCUs
- Includes development resources and manual (examples for Raspberry Pi, Jetson Nano, Arduino, STM32)
- Operating voltage: 3.3V/5V
- Interface: 3-wire SPI, 4-wire SPI
- Full refresh time: 6 seconds
- Partial refresh time: 0.3 seconds
- Refresh power: 24mW (typical)
- Standby current: less than 0.01uA (almost none)
- Dot pitch: 0.217 × 0.217 mm
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.