Description
- 1x Waveshare 5.79" E-Paper Display Module, E-Ink Display, 792x272, Black/White, SPI Interface
- 1x 5.79inch e-paper module
- 1x GH1.25 9pin cable 20cm
- Outline Dimensions: 152.5 x 58.5 mm
- Display Size: 139 x 47.74 mm
- Resolution: 792×272
- Viewing Angle: >170°
- Display Color: Black/White
- Grey Scale: 4
- Communication: SPI
- Display Panel: E-paper
- Experience: Paper-like
- Environment: Ambient light required
- Display Type: Passively reflective
- Refreshing: Partial refresh support
- No backlight; retains last content even when powered down
- Ultra-low power consumption; power needed only for refreshing
- SPI interface for connecting with controller boards like Raspberry Pi, Jetson Series, Arduino, STM32
- Onboard voltage translator compatible with 3.3V/5V MCUs
- Includes online development resources and manual (driver board circuit diagram, examples for Raspberry Pi, Jetson Series, Arduino, STM32)
- Operating Voltage: 3.3V/5V
- Interface: 3-wire SPI, 4-wire SPI
- Full Refresh Time: 3.5 seconds
- Partial Refresh Time: 0.8 seconds
- Dot Pitch: 0.1755 × 0.1755 mm
- Refresh Power: <50 mW
- Standby Current: <0.01 µA (almost none)
- E-paper display uses microcapsule electrophoretic technology
- Onboard SPI Control Interface for use with controller boards like Raspberry Pi, Jetson Nano, Arduino, STM32
- PWR: Power on/off control
- BUSY: Busy status output pin
- RST: External reset, low active
- DC: Data/Command selection (high for data, low for command)
- CS: SPI chip selection, low active
- CLK: SPI SCK pin
- DIN: SPI MOSI pin
- GND: Ground
- VCC: Power (3.3V / 5V input)
- Onboard Voltage Translator: Compatible with 3.3V / 5V MCUs
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.