Description
- 1x Waveshare Open405R-C STM32F4 Development Board, Package A
- 1x PL2303 USB UART board (mini) v2
- 1x USB Type A plug to mini-B plug cable
- 1x USB Type A receptacle to mini-B plug cable
- 1x 4-pin 2-pin wires pack
- 1x USB power cable
- 1x 2.8-inch resistive touch LCD
- 1x Analog test board (for testing embedded AD/DA)
- 1x USB3300 USB HS board (ULPI)
- 1x SN65HVD230 CAN board (CAN)
- 1x FM24CLxx FRAM board (I2C)
- 1x Micro SD storage board (SDIO/SPI)
- 1x Ethernet cable
- Core: Cortex-M4 32-bit RISC
- Operating Frequency: 168 MHz, 210 DMIPS/1.25 DMIPS/MHz
- Operating Voltage: 1.8V-3.6V
- Package: LQFP64
- Memories: 1MB Flash, 192+4kB SRAM
- MCU Communication Interfaces: 3 x SPI, 4 x USART, 2 x UART, 2 x I2S, 3 x I2C, 1 x SDIO, 2 x CAN
- USB 2.0 HS/FS Device/Host/OTG Controller with Dedicated DMA, On-Chip Full-Speed PHY
- USB HS ULPI (External PHY Required)
- AD & DA Converters: 3 x AD (12-bit, 1μs, Shares 16 Channels); 2 x DA (12-bit)
- Debugging/Programming: Supports JTAG/SWD (Serial Wire Debug) Interfaces, Supports IAP
- AMS1117-3.3V Voltage Regulator
- MIC2075-2: Onboard USB Power Management Device
- Power Supply Switch, Powered from 5Vin or USB Connection
- Boot Mode Selection, for Configuring BOOT0 Pin
- Power Indicator
- VBUS LED
- Reset Button
- 8M Crystal
- 32.768K Crystal, for Internal RTC with Calibration
- JTAG/SWD Interface: for Debugging/Programming
- USB Connector, Used for Establishing USB Communication Between PC and the STM32 Development Board
- MCU Pins Expander, VCC, GND and All the I/O Pins are Accessible on Expansion Connectors for Further Expansion
- 5Vin Pinheader, 5V Power Supply is Required When Using USB HOST/OTG
- USB Jumper
- VBAT Selection Jumper
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.