Description
-
1x Compute Module IO Board Plus
-
1x DS18B20 Temperature sensor
-
1x IR remote controller
-
1x LCD adapter
-
1x 22pin FFC
-
1x RPi Zero V1.3 camera cable 15cm
-
1x Power adapter 5V/3A Micro
-
1x USB Type A plug to Micro B plug cable 120cm
-
1x Jumper wire 4-pin to separated pins
-
1x Jumper wire 2-pin 2.54-pitch 200mm
-
Waveshare Raspberry Pi Compute Module 3+ Development Kit Type A (no CM3+, US)
- Broadcom BCM2837B0
- Cortex-A53 (ARMv8) 64-bit SoC @ 1.2GHz
- 1GB RAM
- eMMC Flash
- 200-pin SODIMM connector with 35U hard gold plating I/O pins
- 48 GPIO
- 2 I2C
- 2 SPI
- 2 UART
- 2 SD/SDIO (1 SD used for eMMC Flash on non-Lite variants)
- 1 HDMI 1.3a
- 1 USB2 HOST/OTG
- 1 DPI (parallel RGB display)
- 1 NAND (SMI)
- 1 4-lane CSI Camera Interface (up to 1Gbps per lane)
- 1 2-lane CSI Camera Interface (up to 1Gbps per lane)
- 1 4-lane DSI Display Interface (up to 1Gbps per lane)
- 1 2-lane DSI Display Interface (up to 1Gbps per lane)
- Compatible with the Compute Module IO Board V3 from the Raspberry Pi Foundation
- Raspberry Pi GPIO header for connecting various Raspberry Pi HATs
- Arduino connectivity, supports Arduino shields
- 1-WIRE interface for connecting single-bus devices like DS18B20
- 4 keys, 4 LEDs, 1 Buzzer for I/O testing
- Onboard USB HUB for connecting more USB devices
- IR receiver, IR remote control available
- Onboard USB to UART for serial debugging
- Sensor interface
- 10-bit ADC, 38KSPS, 11 channels (6 channels for Arduino interface, 5 channels for sensors)
- 16-bit DAC, 2 channels
- Onboard RTC, a common and useful function
Estimate shipping
WARNING: This product can expose you to chemicals including lead and lead compounds, which are known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov.